Product ID:TEL-X AEROSOL, 5063
MSDS Date:12/02/1988
FSC:6850
NIIN:00N009340
MSDS Number: CCBRS

NATIONAL CHEMSEARCH DIV OF NCH CORP

IRVING, TX 75015
US

Emergency Phone: 214-438-1381

Info Phone: 214-438-1381

Preparer: KARLA BOELTE

Cage: DO481

NCH CORP

152170 IRVING, TX 75015-2170 US

Telephone: 972-438-0563

Cage: 20913

ETHANE, 1,1,1-TRICHLORO-; (1,1,1-TRICHLOROETHANE) (SARA

CAS: 71-55-6

RTECS: KJ2975000

OSHA PEL 350 PPM

ACGIH TLV: 350 PPM/450STEL;9495

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

LD50 LC50 Mixture:LD50: (ORAL, RAT) 10,300 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:CHLOROCARBON MATERIALS HAVE PRODUCED
SENSITIZATION OF THE MYOCARDIUM TO EPINEPHRINE IN LABORATORY
ANIMALS AND COULD HAVE A SIMILAR EFFECT IN HUMANS. ADRENOMIMETICS
(EG, EPINEPHRINE) MAY BE CONTRA-INDI CATED EXCEPT FOR
LIFE-SUSTAINING USES IN HUMANS ACUTELY/CHRONICALLY EXPOSED TO
CHLOROCARBONS .(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:ACUTE:HEADACHE, BLURRED VISION,
NAUSEA, & DIZZINESS. WHEN THE TELOMER IS EXPOSED TO TEMP ABOVE
750F, CONDITION KNOWN AS TELOMER FEVER HAS OCCURED FROM EXPOS TO
FUMES OF DECOMP BY-PRODUCTS. CH RONIC:PRLNG INHAL CAN CAUSE CNS
DEPRESSION & CAN LEAD TO ASPHYXIA. MARKED IRRIT TO EYES & SKIN DUE
TO ITS DEFAT NATURE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHAL:MOVE TO FRESH AIR & TREAT SYMPTOMATICALLY. GIVE OXYGEN
IF BRTHG IS DFCLT. GIVE ARTF RESP IF BRTHG STOPS. GET MED HELP.
EYE:FLUSH W/H*2O FOR AT LEAST 15 MIN. SEE MD IF IRRIT PERSISTS.
SKIN:WASH W /SOAP & H*2O. IF IRRIT DEVELOPS, SEEK MED ATTN.
INGEST:DO NOT INDUCE VOMIT EVEN IF VOMIT OCCURS. IF IT OCCURS, KEEP
HEAD BELOW HIPS TO PVNT ASPIR OF LIQ INTO LUNGS. GET MED ATTN
IMMED. (SUPDAT)

Flash Point:NON-FLAM
Extinguishing Media:FOAM, CO*2.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD PRESSURE DEMAND SCBA &
FULL PROT EQUIP . HIGH CONC IN CLOSED AREA CAN BURN. SHOULD NOT BE
USED IN CLOSED EQUIP WHICH MAY (SUPDAT)
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION PRODUCTS MAY
INCLUDE HCL AND PHOSGENE . UNDER EXTREMELY HIGH HEAT, PHOSGENE OR
FLUORINE COMPOUNDS CAN BE FORMED.

Spill Release Procedures:PREVENT FROM ENTERING SEWER/WATER SOURCES.
VENT ENCLOSED SPACE. WEAR RESPIRATOR. CLEAN UP (ANY ELECTRICAL
CLEANING EQUIPMENT MUST BE EXPLOSION-PROOF) OR SOAK UP WITH SAND,
COTTON WASTE/OTHER ABSORBANT MATERIAL. AEROSOL PACKAGING MINIMIZES
THIS HAZ.
Neutralizing Agent:NOT APPLICABLE.

Handling and Storage Precautions:STORAGE TEMPERATURE 120F MAX 30F MIN.
FOLLOW LABEL DIRECTIONS.
Other Precautions:NO SMOKING IN AREA OR USE. DO NOT USE IN THE GENERAL
VICINITY OF ARC WELDING, OPEN FLAMES OR HOT SURFACES. HEAT AND/OR
UV RADIATION MAY CAUSE THE FORMATION OF HCL AND/OR PHOSGENE . KEEP
OUT OF R EACH OF CHILDREN.

Respiratory Protection:TYPICAL USE OF PROD DOES NOT REQ THE USE OF A
RESPIRATOR. IF PRODUCT IS MISTED USE NIOSH/MSHA APPRVD MASK FOR
SPRAY MISTS. IN EMERGENCY SITUATIONS FOLLOWING RESPS ARE REC:500PPM
CCROV/SA/SCBA. 1000PPM CCROVF/GMOV/SAF/SCBF. ESCAPE:GMOV/SCBA.
Ventilation:SUFFICIENT VENTILATION TO BE EQUAL TO OR BELOW THE
ALLOWABLE CONCENTRATION.
Protective Gloves:VITRON, PVA OR EQUIVALENT.
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS .
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC: RETAIN SOLVENT RESIDUES. FIRST AID PROC: NOTES TO
PHYSICIAN:DEPENDING ON AMOUNT INGESTED & RETAINED AS WELL AS THE
TOXICITY OF THE PRODUCT, GASTRIC LAVAGE SHOULD BE AVOIDED BECAUSE
OF PULMONARY ASPIRATION. IF COMATOSE, A CUFFED INOTRACHEAL TUBE
WILL PREVENT ASPIRATION. CONSULT A POISON CONTROL CENTER.

Boiling Pt:B.P. Text:>115F,>46C
Vapor Pres:100
Vapor Density:4.8
Spec Gravity:1.40 (H*2O=1)
Evaporation Rate & Reference:<1 (BU AC = 1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WHITE; CHLORINATED HYDROCARB ODOR.
Percent Volatiles by Volume:95

Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES, ACIDS AND SELECTED AMINES.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:DECOMPOSITION TEMPERATURES CAN RELEASE
CARBON DIOXIDE/MONOXIDE. HYDROGEN CHLORIDE, PHOSGENE AND FLUORINE
COMPOUNDS.

Waste Disposal Methods:DISPOSE OF AEROSOL IN TRASH AFTER WRAPPING IT IN
SEVERAL LAYERS OF NEWSPAPER. FOR DISPOSAL OF WIPING MATERIALS,
CHECK WITH ALL FEDERAL, STATE AND LOCAL POLLUTION CONTROL
REGULATION.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.